Hi everyone,

As per title,

I have a 1990 L300. My (colum change) shifter is "sloppy" (i.e: goes into gear not a worry, but theres alot of play in the gear lever). Just wondering if anyone here, could tell me how to remedy this problem. Its the first Mitsi I've ever owned, and I know nothing at all about it ...

Hi all, looking to purchase a camper and have found this;



Any comments? Anything I should be looking for? Is changing the rad a big job?

Thanks! default/liebe011.gif' 'liebe011.gif' />...

Hi ,

I' have a L300 4WD 2.0 equiped with the 4G63 carb. 2.0.
My van is one of the very last 1983-1986 version, a couple of months before the model was revised and improved by Mitsi.

My power steering pump is out of order,
and I try to find one on the internet.

So, I desperately need the misti part number for this one....

Thank you in...

Hey, does anyone have a wiring diagram for a 1991 Delica Starwagon 2.5TD? Because if anyone happens to have one we would greatly appreciate it...

Hi All
This is my first venture into mitsubishi's. I have an 1988 L300 express and was wondering if anyone can emaile a electrical diagram and also can anyone give me some advice on the steering. It has a bit of play in the steering wheel and was wondering what is the normal problem and repair option.
I look forward to a responce from anyone.

Cheers.

gday all, im wondering about the firing order of my 10/91 starwagon..and which way the distributor turns. engine is 4G63.
cheers.

howsit,

Iv got a problem with my L300 missing, pretty bad now, it wont even move the van.
Its a 1991 2L petrol, 4G63 carby 8valve

iv gone through and replaced all the usaul things, like plugs, leads, dizzy cap, rotor.
Iv reset all the tappets, changed the carb...

Is there anything that i might have missed? or some common problem that these motors give?...

hi all,
can anyone please tell me how to adjust timing belt, there is a round hole in timing cover, buts thats all i know, not sure what to do next. needs just a little tighter, thank you all! default/banana.gif' 'banana.gif' />

Hey,

I've got a 94 Starwagon 2.4L with a loose alternator belt and was wondering if anyone could give some instructions/guidance on how to adjust it and if possible send any pages from workshop manual that would be of any use.

Hi Guys !

I'm the proud new owner of a L300 4WD 2.0 equiped with the 4G63 carb. 2.0.
My van is one of the very last 1983-1986 version, a couple of months before the model was revised and improved by Mitsi.

My ignition system (engine 4G63 2.0 sohc) is *not* electronic but old school mechanical.

I live in France where parts are very hard to find since...

Our Pajero 4DR54 engine timing belt B breaks but the engine is works. How does this timing belt B function? What is the effect on the engine running without timing belt B

Recently my wife rolled our 97 3.5 GDI Pajero and it looks like it may be a write off. While I'm a fan of the truck my family is outgrowing its limited internal space. I need a 4WD and seven seater and am considering a Delica or Spacewagon van. Can those in the know please tell me the pros and cons of the van and what is the most desirable year/model/engine to get please?

Thanks,...

Hi Guys!
I've got a 2,8 Delica with electronic injection pump with the engine light on.
Has anybody got a clue where to start looking,when you haven't got a scanner? default/gitara.gif' 'gitara.gif' />

Hi, we're trying to repair a 4wd gearbox on 1985 Express L300 4X4, have bought 2nd car and replaced gearbox, but now can't get 2nd and 4th. Help?!
Original gearbox, wouldn't select some gears, then only when clutch was released, till no longer working at all.
New gearbox in now, but can only get 2nd on occassion once revs are up in 1st and slam gearstick into 2nd, but 4th...

My 1993 Express 4wd has, in addition to the normal oil pressure warning light, a similar looking one but with a wavy line under the oil can as if indicating a liquid. What's that warning light for?
Thanks.

Can anyone help my space gear will stall after approx 1 mile ,if left to warm up for 10 mins it will not do it and once restarted it is fine .There is a bit of smoke when restarted but i think that is excess fuel ,it runs fine once it has done this with no power problems and no smoke .The garages who have looked at it have no idea .

Hey, guys, the fuse box cover on my family's 1991 Delica Exceed is in Japanese, and, well, none of us know Japanese so I was wondering if there might be anyone out there who could give us a translation... I've included a picture of the fuse box cover in the attachment, it has good resolution so I think it'll be legible...

Hey all. I just picked up a starwagon 1987 here in the states. We just called them vans, but anyhow.

The wiring is fubar. The **** who owned it before me cut all teh wiring out around the battery. I've managed to piece together about 80% of the wiring from misc 80s mitsubishi vehicles from the jyard, but I sitll dont have it finished. I can start the van and it will run, but some...

hey there mitsi guys

Got me a L300, cleaning it up and have had ideas about powering it with a VR4 or and injected 4G63, something to make it more of a drivable Van.

and i was wondering if any of you guys cud suggest anything, or maybe a site that would lead me in the rite direction.

thanks JP

I have just purchased a 1984 Mitsubishi Express L300 4WD (in need of repair) and am looking to get a copy of the workshop manual. I have searched on the internet but can't seem to find the workshop manual for the 4WD model. Any information would be great.

Hi all

I've recently satisfied my long time desire to own a van. The van that caught my eye was a 96 Starwagon Satellite. It runs really well (it has the 2.0 litre engine), by no means neck breaking but its honest.
When i bought it there was some trouble getting it into 4th gear (overdrive) but the people I bought it from were able to fix it before I took delivery of it....

how ya going? my l 300 4d56 diesel been going thru a bit more oil lately. in the morning when she's cold it will smoke for about 5 minutes, after that it's gone. it's a 88' and still goes strong. did a little experiment, let the oil go down to the low mark, but then it stayed steady, no worries. i will replace the oil sump gasket at next oil change. a mechanic told me it could be a...

Hi,

apparently something went wrong with the steering coulomn of my L300 4WD. The garage will not search for the problem in the coloumn but proposes to replace the whole steering coulomn by a L300 2WD one (450 euros).

I ask myself if:
- this is possible (my L300 is a 1994 model)?
- repairing the problem inside my 4WD steering coulomn isn't a better/cheaper...

Can anyone help me with a diagram of the top part of the p/s pump on 89 starwagon where the hose connects. Mine is leaking and when i went to buy 2 rubber o rings at mits the computer said there were 4 ,probably why mines leaking.The cost is $128 for the 4 as a kit. I can see where the 3rd may fit but not the fourth.Also if anyone knows of aftermarket ones that can be used ,please let me...

Hi there, can anyone tell me which other models/years i can poach parts off for a 1985 4wd l300, they're pretty rare around here and apparently changed completely after 1985 so im at a bit of A loss for info - even mitsubishi motors cant tell me much (or even find me a workshop manual!)
-cheers, Dogfoot.

Hello everyone,iv just joined so this is my first post.Good to see theres still a few people that still appreciate the L300 4wd.I have a project van ,its fitted with a 2.6 and i believe the conversion was done by gossies,it has a electric fuel pump at the rear of the chassis rails that constantly ticks,i dont know if this is an origanal l300 item,but no fuel,the pump has 4 lines,does anyone know...

Hi Guys, I have an 89 2.0 ltr starwagon that has just had the motor reconditioned and when i got it home noticed an oil leak. Back to the mechanic and he put it on the hoist and said it was coming from the fuel pump so after $3695.00 i spent $80.00 on a new pump fitted free and have discovered oil on the ground again. The mechanic said that he thought it was the power steering pump as...

Has anybody got a fan shroud to fit my 89 2 ltr starwagon with a standard single core radiator ,and would you like to sell it ?

I have a 1990 l300 2.0litre petrol and i had a leaking water pump. I removed the timing cover only to realise that the balance belt had snapped also.

I have two questions,
1: Is the only way of replacing the belt by removing the crankshaft?!
2: What would happen if I didn't replace the belt?

The alternator of my 85 l300 is shot. 2 Litre version. The wrecker quoted $250, saying it was special in some way, internal somethingorother, yes I know nothing about cars, but am I having the wool pulled over my eyes? What's the spec number for the alternator? Maybe I can find another one on Ebay.

Hey folks.

I have a 1990 L300 LWB Cyclone 2.0litre petrol and I want to replace a leaking waterpump.
Any advice, suggestions or if possible some diagrams of waterpump postion, timing belt set-up etc.
I'm under pressure for time so any speedy response would be hugely appreciated!
I have plenty of mechanical experience changing belts pumps etc but never on an L300.

hey guys own a d-50 ute with a 4g63 sohc carby fed engine witch came out of a l300 to know knowlage i want some more power and i dont know were to start ive got the exhust and extractors done to it ive been googleing heaps not much good mainly evo engines come up... this is what i would like to do
wack a 12psi superchager on it
stonger internals{dont know were to look our how to go about...

hi
i am new in the forum and live in the philippines. i have a delica 1991
i bin looking for a repair manual downloade.
the problen is the monytransfair its not save bey internet. sombody knows a link ?
regards
gerhard

That sure was a noisy drive to the bus station!
Leaving my driveway my horn in the 85 Starwagon was starting to beep slightly on its own. 5 minutes later I was sounding a wake up blast to all of Brisbane before I removed the fuse and killed the earsplitting sound.

Q1- What causes the horn to blast constantly? Is it most likely a horn relay fault?

Q2- Is there a test...

Hi I was just wondering where could I find the chassis number of my L300 is it in the left side or the right side?? Thx

Heh there,
I've tried searching the forum for anything on how to setup the headlights on my l300 starwagon for driving on the right hand side of the road with no luck. Was hoping that someone may have already posted or might have instructions on what I need to do.
Cheers,
Steve

If the belt breaks can the valves hit the piston on the 2.4i engine?

The recommended replacement distance is 100 000kms. Does anyone know on average at what distance the belt would snap if it was never changed?
Thanks.

I have a japanese manual and I want to know what ro do next when i have 'wheelk lock' shozing on the dashboard.
thanks a lot

default/00000732.gif' '00000732.gif' />

Hey

I just bought a L300 4x4, and I'm wondering if there's a tech schematics book for this car availible, and from where you can buy the cheapest spareparts.

Hi all, My friend is interested in buying a Delica L300 2.5td, but needs an engine and box for it. I have an auto box spare from a 2.5 mk1 pajero. Will this fit straight in or are they different? Also are the engines exactly the same in both vehicles? (As there are a lot more Pajero engines out there than delicas!!) Any knowledge would be greatly appriciated...

Any suggestions for a new set of shockies for my L300 4wd, which I use in the mountains in New Zealand

Hi,
I am new to this forum.
I have a modified L 300.
Can anyone tell me if the 2 wd and 4 wd Express vans use the same steering rack.
Thanks and Regards, Al

Hello to all on this forum im new here .
Im in some trouble , I need the wiring diagram for the efi side of things for a 1989 L 300 express van with the 4g64 , 2.4 engine .
these things seem to change wiring depending on the year .
my ecu has only 2 plugs , a 24 pin and a 25 pin ( i think)
any help will be apeciated.
Dave

I need to replace my input shaft bearing on my 85 l300 4x4 gearbox. once i pull the box out can i just unbolt the front bearing retainer and pull the shaft out or do i need to dismantle the box. Had it fully rebuit about 5 years ago but i tow a trailer every day and the strain is starting to take its toll.

Hi, I would love to find out how to get my (old) new 89 L300 back onto the road.

The motor has been rebuilt and is installed, BUT, ive taken the alarm out and have reconnected the wiring as per normal use...

I am UNABLE to get the motor to turn over at all!

I need to find out where all the wires are supposed to be connected?

I have the DOOR LOCK fuse...

1. Hi, saw your name on the chat room thingy, would you mind telling me
where I can find a user manual for my model van online? I just got a van
I want to turn into a camping wagon, but someone has fucked all the
wiring in the van so I’m trying to reconnect all the original wiring from
scratch... HELPPPPPP! haha.
Thanks if you can help, Mat. (New Zealand)

Hi...

I've just picked up a L300 2.5D work van SWB.
The seller mentioned a "rattly exhaust",and when I bought the van I assumed it was just the baffles in the box rattling,but I now realise its had a bodged repair after the box,and the pipe ends next to the spare wheel cage!!
I read online about recalls to do with a weak exhaust.
So looking up the exhaust online and...

Many have converted to the 2.6 and I have researched the hassels and effort's of the conversion changing sump,modifing sump ect....
There is a easyer way...!
I have just trial fitted the starion/cordia 1.8 turbo and it fits so easy....swap the sump and pick up off the old 1.8 engine and mounts and she's in i have no intension of running the ecu as I am using a straight gas...

I have a 1998 WA Starwagon GLX (Auto) that has done 235000Kms. On idel mainly if aircon is on and when started it blows alot of blue smoke. Does anyone know if this would be due to stuffed oil seals or valves or could it be the rings. It does not blow smoke when accelarating. From the day i bought the van it has always seemed very gutless. Is this normal for this model van?
Dave.